10/11
ATV
KIMPEX INC.
/ 5355, rue St-Roch / Drummondville (Québec) Canada / J2B 6V4
KIMPEX USA
/ 100 Walnut Street / Champlain, New York / 12919
Lithographié au Canada / Litho’d in Canada
2810418
A-2810418
FRONT AND REAR A-ARM BRACKET KIT
Kimpex
#
375121
For Commander WIDE TRACK, WTX, and TREX Track Kits
MOUNTING INSTRUCTIONS
10
"COMMANDER TREX"
REAR ANTI-ROTATION ARM BRACKET INSTALLATION
1)
Remove the plastic cap (#
A
) (
see sketch N
).
2)
Assemble the rear part of the rear right anti-rotation arm bracket
(#
3
) into the two mounting holes made for this purpose in the
frame of the Track Kit using
(2) 3/8” nc X 1”
hex bolts (#
14
) and the
(2) 3/8” dia
lock washers (#
12
) (finger tighten at this time) (
see
sketch O
).
3)
Position the clamping round plate (#
5
) where the plastic cap was
removed in
step 1
and fasten the front part of the anti-rotation
arm bracket (#
3
) to frame using a
3/8” nc X 7”
hex bolt (#
19
) and
a
3/8” nc
self-locking nut (#
17
) (
see sketch O
).
4)
Torque to 20 ft-lbs.
5)
Repeat
steps 1
to
4
for the opposite side.
“COMMANDER WIDE TRACK, WTX, AND TREX”
REAR ANTI-ROTATION INSTALLATION
(see sketch P)
WARNING:
Prior to installation, turn off the engine, put
in two-wheel driving mode, and block the wheels.
1)
Raise the rear of the ATV off the ground and remove the wheels.
WARNING:
When the ATV is raised, make sure that it is
properly secured/supported to prevent it fromaccidentally
falling during the installation. If not properly secured/
supported, serious physical injury could occur.
2)
Screw the
5/8” nc
nut (#
16
) onto the threaded part of the anti-
rotation arm (#
9
).
3)
Install the
17 mm I.D. X 50 mm O.D. X 3 mm
flat washer (#
7
) and the
bushing spacer tube (#
2
) onto the threaded part of the anti-
rotation arm (#
9
).
4)
Install the rubber bushing (#
1
) over the bushing spacer tube
(#
2
).
5)
Slide the anti-rotation arm assembly into the hole of the rear
right anti-rotation arm bracket (#
3
).
sketch N
sketch O
RIGHT
REAR VIEW
Rear of
the ATV
Rear of
the ATV
RIGHT
REAR VIEW
sketch P
Rear of
the ATV
RIGHT
REAR VIEW
