2810255
KIMPEX INC.
/ 5355, rue St-Roch / Drummondville (Québec) Canada / J2B 6V4
KIMPEX USA
/ 100 Walnut Street / Champlain, New York / 12919
Lithographié au Canada / Litho’d in Canada
A-2810255 Rév. B
ATV
MOUNTING INSTRUCTIONS
FRONT AND REAR A-ARM BRACKET KIT
Kimpex
# 375214
FOR " COMMANDER WIDE TRACK " AND " COMMANDER TREK " / HONDA FOREMAN 2006
REAR ANTI-ROTATION INSTALLATION
(see sketch K)
WARNING :
Prior to installation, turn off
the engine, put in two-wheel driving mode,
and block the wheels.
1)
Raise the rear of the ATV off the ground and
remove the wheels.
WARNING :
When the ATV is raised, make
sure that it is properly secured/supported to
prevent it from accidentally falling during
the installation. If not properly
secured/supported, serious physical injury
could occur.
2)
Screw the
5/8” nc
nut (#
15
) onto the threaded
part of the anti-rotation arm (#
4
).
3)
Install the
17mm I.D. X 50mm O.D. X 3mm
flat washer
(#
21
) and the bushing spacer tube (#
2
) onto the
threaded part of the anti-rotation arm (#
4
).
4)
Install the rubber bushing (#
1
) over the bushing
spacer tube (#
2
).
5)
Slide the anti-rotation arm assembly into the hole
of the rear right anti-rotation arm bracket (#
7
).
(see sketch L)
6)
Fasten the other end of the rear anti-rotation arm
(#
4
) onto the rear anti-rotation arm support (#
6
)
installed in
step 2 at the “SNOWPLOW
ADAPTER INSTALLATION”
using the
3/8” nc X 3”
hex bolt (#
12
) and the
3/8” nc
nylock nut (#
18
).
(see sketch K)
7)
Install the rubber bushing (#
1
), the
3/4” I.D. X 2”
O.D. X 1/8”
flat washer (#
20
), and the other rubber
bushing (#
1
) over the bushing spacer tube (#
2
).
8)
Install the
17mm I.D. X 50mm O.D. X 3mm
flat washer
(#
21
) onto the threaded part of the anti-rotation
arm (#
4
).
9)
Screw the
j
self-locking nut (#
19
) onto the
threaded part of the anti-rotation arm (#
4
). Do
not overtighten.
NOTE :
Refer to the Track Kit manual for
the correct adjustment.
10)
Repeat
steps 2
to
9
for the opposite side.
sketch K
RIGHT
REAR VIEW
Rear of the ATV
6
18
4
12
sketch L
Rear of the ATV
9/11
